ENERGY SAVING TECHNOLOGY OF DRYING SEEDS IN THE DRYER CHAMBER FLOOR TYPE

A V Kozlov; V I Hilko

doi:doi:

UDC 631.362

ENERGY SAVING TECHNOLOGY OF DRYING SEEDS IN THE DRYER CHAMBER FLOOR TYPE

Published в Bulletin of KSAU · Issue 11, 2015 · Pages 85–89 · Rubrics: TEHNIChESKIE NAUKI PROCESSY I MAShINY AGROINZhENERNYH SISTEM

Received: 21.11.2015 Accepted: 23.11.2015 Published: 25.11.2015 Language of publication: RUS

Authors

A V Kozlov ¹ · V I Hilko ²

1 Far East Mechanization and Electrification of Agriculture Research Institute

2 Far East Mechanization and Electrification of Agriculture Research Institute

ABSTRACT

In the article the questions of rational modes of energy saving technology for drying of seeds and substantiation of possibility of creation of technological regimes to the dryer cyclic operation when working in the production line are studied. The aim of this work is to improve the dryer of the chamber type with sloping floors. The efficiency of using the combined two-stage drying in a dryer of this type is investigated. The technological scheme of operation of the dryer after the upgrade is included. The optimal combination of processing methods laid down in is developed the technological scheme of drying seed grain of high humidity, allows IP to use their pre-emptive hand: holding of grain drying in a single pass to the required of conditions; soft drying mode, compared to the shaft dryers; simplicity of design of grain dryers; grain drying to form modules of blocks of different drying performance.

KEYWORDS

seed grain dryer floor type modernization

Information Text References

Authors:

1. Far East Mechanization and Electrification of Agriculture Research Institute

2. Far East Mechanization and Electrification of Agriculture Research Institute

Type:

Article

Pages:

from 85 to 89

Status:

Published

Subject area:

UDC 631.362

Language:

Russian

Keywords:

seed grain, dryer floor type, modernization

Text

Text (PDF): Read Download

References

1. Mel'nik B.E. Spravochnik po sushke i aktivnomu ventilirovaniyu zerna. - M.: Kolos, 1980. - 148 s.

2. Manasyan S.K. Kamernaya zernosushilka // Vestn. KrasGAU. - 2009. - № 2. - S. 166-170.

3. Golubkovich A.V., Pavlov A.S. Teplomassoperenos pri dvuhetapnoy sushke zerna // Sel'skohozyaystvennye mashiny i tehnologii. - 2010. - № 4. - S. 26-29.